I was very fortunate in that my Flight Instructor, Lieut. Herbie Becker, was an excellent instructor who knew the aircraft inside out and was able to pass this knowledge on to me. I am sure that had it not been for him I would almost certainly not have had the in-depth understanding of the Flight Fine Pitch Stop system in the Gannet which stood me in such good stead later; knowledge which went a long way towards saving my life and those of my crew.
When embarked, the Gannet aircraft routinely averaged sortie times of around 3-4 hours. Anti-Submarine equipment was not much more than the MK1 Eyeball! A basic radar (ASV19B), a mix of mainly non-directional and a small number of directional sonobuoys, and a small number of hand launched smoke markers completed the A/S detection kit. It was also possible to carry two homing torpedoes, a few depth charges or a small number of 250 lb. bombs either in the bomb bay or on wing racks, and occasionally 60lb rockets. That completed the ASW capability.
Standard operating procedure called for normal cruise configuration to be on single engine in order to conserve fuel. Anti-submarine search operations were routinely below 1500 feet in all weather, day and night. The single-engine cruise protocols called for the operating engine to be swapped hourly in order to even out the running hours. Operations were normal for the first year or two utilizing the above-mentioned protocols. However, it was not long before aircraft began suffering engine failures at a disturbing frequency, almost always preceded by a rapid loss in oil pressure. This resulted in an increase in single engine deck landings, something to which pilots did not look forward, particularly in heavy seas and/or bad weather. Eventually Fairey Aviation discovered that the prolonged single engine cruising was causing ‘Brinelling’, or pitting, of the propeller bearings in the feathered propeller. This in turn was causing metal particles to be distributed through the oil into both engines and propellers due to the single oil supply tank … the first of the two stings in the Gannet tail!
The quick fix was to change the single engine cruise protocol to ensure equal distribution of the time in the feathered position; rotating the feathered engine slightly every ten minutes, and changing operating engines every 30 minutes. All this had to be accomplished while possibly actively tracking a submarine, often at 300 feet on a pitch-black night and possibly in bad weather – and no co-pilot to assist! There were many single engine landings, both day and night on board Melbourne, caused almost exclusively by this problem. This was worrying enough without the knowledge in the back of the pilot’s mind that the pieces of metal in the joint oil supply could result in the second engine failing at any time! Many times the pilots missed the wires due to float, deck movement or both – resulting in a BOLTER. However, on 6 June 1958, on completion of a night flare dropping exercise, I again experienced an engine failure – which resulted in a dreaded night BOLTER followed by a successful recovery. Another ‘first’.
It was a very warm night in South East Asia and the sea was relatively flat with only about 10 knots of wind. Having suffered what was now a routine engine failure, I elected to perform a straight in landing. This was probably an error in that it caused difficulties in attaining and holding the correct approach speed, such that the aircraft was approximately 5 knots fast over the round-down and floated over all the arrestor wires. I immediately applied full power to the operating engine and raised the undercarriage but was unable to climb away. The aircraft settled towards the water but held altitude just above the surface in the ground effect. The altimeter was reading zero, and the needle on the Radar Altimeter, calibrated in 10 feet increments, was hovering just above zero – but not even half way to the 10 feet marker. As the aircraft passed down the port side of the Rescue Destroyer stationed on the Starboard Bow of the Carrier, the Port Running Light on the bridge was above the eye level of the crew in the Gannet. After what seemed an eternity, the Radar Altimeter began reading a healthy 50 feet above the water, and raising the flaps was commenced in stages. A very wide, climbing circuit was established, levelling at 1,000 feet down-wind. From there, a normal single-engine landing was completed, followed by several medicinal rums in the sick bay afterwards! This was the first and only successful night bolter and recovery ever in either the RAN or RN. I believe it remains so to this day. My crew comprised Lieut. Evans (Observer) and Obs. 1 Hancox (Tel).
Sting in the tail
Getting back to the Gannet peculiarities, the second sting in its tail – which caused many accidents and injuries, including death – was a little thing called the Flight Fine Pitch Stop. Essentially, this was a pin which prevented each propeller from moving into the fully fine position when the throttles were retarded as for landing, unless the landing gear was down and locked. This stop was actuated (inserted) by the landing gear coming up, and removed by it on lowering for landing. When the propellers were allowed the full movement into the full fine position, they effectively presented two solid disks to the airflow, causing enormous drag and potential for uncontrollable loss of altitude. Of course, this was of little concern when at altitude or when within inches of the ground in the normal landing with the gear down. However, in the single engine configuration, this drag was not at all desirable – so there were two Flight Fine Pitch Stop Override (FFPSO) switches in the cockpit with which the withdrawal of these pins (one on each propeller) was prevented, either individually or together when the landing gear was lowered. Of course, when attempting a single engine landing, the lack of this drag in the final landing phase (assuming the pilot had remembered to make the FFPSO switches) could result in a float before touchdown. This was of no consequence when landing on a runway – but caused untold difficulties in the final phase of a deck landing! It was invariably this, in association with possible deck movement, which caused the aircraft to float over the wires and BOLTER!
The ability of the Gannet to fly around at low level on one engine with hook down, bomb-bay doors open and radome lowered made the aircraft a great crowd pleaser at flying displays. This act was sometimes varied by turning down wind at the end of the runway after the low fly-past, closing the bomb-bay doors, raising the hook and radome while in the turn, and then lowering the undercarriage to complete a single engine landing as a finale. This always impressed the crowd. However, had the pilot not taken the precaution of selecting the FFPSO ON for the live engine, the lowering landing gear withdrew the FFPS – with the resulting uncontrollable drag and inevitable catastrophic crash! This occurred at NAS Nowra on one occasion, and resulted in very serious injury to the Gannet pilot. This accident resulted in such demonstrations being banned in the RAN.
The odd double vertical folding arrangement for the wings made for quite small ground coverage, but a need for lots of headroom. It did, however, lend itself to inventive initiative at times. Admiral’s inspection at NAS Nowra was always a painful day – and one to be dreaded. Very rare was the day when the inspecting Admiral was not displeased about something. On one particular occasion a flight of Gannets provided a short air display for the Admiral’s benefit. Upon landing, the four taxiing Gannets passed in front of all the Divisions drawn up on the Hard Stand with the Admiral waiting for them to march past in salute. An astute Air Engineering Officer of the Gannet Squadron had disabled the folding mechanism of the port wing in all the four aircraft prior to take-off. As the flight passed the Admiral in line astern formation, the leader ordered the flight to ‘fold wings’. Lo and behold, all starboard wings folded as one in salute to the Admiral, and then spread again after passing the dais! The Admiral was so pleased that he gave the Air Station full marks for their inspection (so the story goes).
Notwithstanding all that has been said, the Gannet was a delight to fly, very light on the controls, very manoeuvrable, with excellent visibility from the very roomy cockpit. Like the albatross and the pelican, which look most ungainly when on the ground, the Gannet was in its element once it shook itself free of the ground and soared into the air. As described by one pilot ‘it was like the fat lady at the barn dance, who you find surprisingly light on her feet, that is how it flew. ’
Note: Originally published in December 2011 edition of the Naval Historical Review (all rights reserved), available at, https://www.navyhistory.org.au/the-fairey-gannet-as1/